南通室外小區公園塑膠地面質量的高低與水泥基礎的要求關系密切，因此要想******限度的延長南通室外塑膠地面的使用壽命，就需要在施工過程中盡可能保證水泥基礎的質量。在鋪設南通室外塑膠地面、塑膠跑道等水泥基礎時，應該適量加入鋼筋，以增加運動場地的整體性，這樣可以起到防止水泥基礎開裂的作用。

　　一般工藝下塑膠面層對水泥混凝土墊層的質量要求1、天然素土層：密度大于95% ，含水率8-12%。鏟除草皮和腐植土后用8-12噸碾壓機沿縱向從兩邊向中間碾壓到5-8遍；2、天然砂石層：厚度150mm左右，******粒徑不超過底層厚度的2/3，骨料含量以60%為宜，用8-12噸碾壓機碾壓5-8遍；3、碎石墊層：厚度為100mm左右，（粒徑30-60mm），用8-12噸碾壓機碾壓到碎石不松動，表面無波紋為止，壓實密度達到2.2噸/立方米；4、隔水層：用聚乙烯薄膜或PVC加厚隔水薄膜待防水卷材，搭接處應大于200mm，邊沿余量大于150mm，保證水泥的固化時間，讓水泥在固化過程中產生的白色粉末完全析出于基礎表面；5、水泥混凝土土層:

　　①應采用250號以上水泥混凝土整體鋪設，表面砂漿1：1；②平板振動后，水泥收漿時用木盒拉毛，使塑膠粘接更牢固；③水泥凝固后，間隔4－5m切伸縮縫（寬8-10mm，深30-40mm）；④水泥混凝土厚度應在100mm左右；⑤強度達建筑混凝土標準C25強度，澆制后保水養護不少于7天，整體固化養護期不少于28天南通室外塑膠地面的水泥基礎有如下要求******，斜度要求：南通室外塑膠地面水泥地面的斜度誤差，要求限制在3‰-5‰以內。如果南通室外塑膠地面地有去水系統，比如大規模清洗，則要求斜度相應增加，并應具備排水地漏或場地排水溝；第二，膨脹縫：在南通室外塑膠地面基礎施工時，需要在整個長方形南通室外塑膠地面中央設15mm膨脹縫橫向貫穿整個球場。移去膨脹物，縫口封上專用填縫料，以防冷熱溫差引起水泥膨脹干裂；第三，干燥要求：根據國際標準，南通室外塑膠地面地面基礎竣工后，需28天以上的養護期，以確保南通室外塑膠地面的地面干燥，保證基礎熱脹冷縮能集中在溫度縫中變化，不回導致基礎其它地方開裂；第四，預埋件：在基礎施工過程中需要為南通室外塑膠地面的其它相關設施預留固定件，預埋件由承攬方提供；第五，去水測試：任何水汪或“鳥澡池”積水深度不得超過一枚硬幣，超過處必須用水泥修補平整；塑膠地面質量要求1、基礎竣工后，水泥面層不得太光滑，不得有起砂、起殼脫皮和裂紋等現象。

　　2、平整度：要求3m直尺誤差不大于3mm

　　3、坡度：符合體育工藝指標。

　　4、抗壓強度：R20>25kg/平方厘米R50>10kg/平方厘米5、一般橫向不大于40/00，縱向不大于20/00，必須保證泄水6、保養期： 室外氣溫25℃以上24天、室外氣溫15℃-25℃之間30天、室外氣溫25℃以下60天（以揮發水泥中的堿性成份，保養期內多澆水）7、塑膠層鋪設前，基礎層應無油、無灰、干燥。